Pacific-cycles CARRYALL Manuel d'utilisateur télécharger pdf

Owner manual

Assembly Procedures

Step 1:

Step 2:

Using the small box to fix the frame and put the

rear chassis as below, set the chainline to

front chainwheel and rear flywheel.

Step 3:

Tighten the mounting plate to the rear chassis

with four M5 bolts, in the meantime set

appropriate chain tightness.

Step 4:

Tighten the rear carrier with 3 M5 bolts.

Step 5:

Open the spring latch, slide the head tube clamp

toward the bottom of the headtube and tighten

the wing bolt with your fingers.

Step 6:

Release the seatpost QR lever, swing seatpost

backwards and fix with seat stay clamp. Open the

QR lever on top of the stem, raise the stem to

desired height, close the QR lever. Insert both

handlebar ends into the center tube, close the QR levers.

Note:

Do not raise the seat higher than the

minimum insertion mark.

Step 7:

Assemble saddle to the seatpost with M6 allen key.

Install the pedals. Turn the right pedal clockwise

and the left pedal counterclockwise to tighten.

Step 8:

How to fold

Step 1:

Loosen the head tube clamp bolt one turn, slide the

ad tube clamp to top by pushing the seat

backward, latch the head tube to the frame.

Step 2:

Un-lock the seat stays from the seat tube, pull the

seat toward the handlebar, open the seat QR lever,

lower the seat and turn it side-ways, latch the QR

lever to the frame.

Step 3:

Open the stem QR lever, lower the stem and turn

the handlebar sideways, close the QR lever.

tep 4:

Fold the pedals.

You are now ready to pull it or carry it!

Don’ts!

• Don’t exceed the maximum

load limits.

• Don’t carry a person or a pet

on the rear carrier.

• Don’t perform stunt riding.

• Don’t jump over curves.

• Don't raise the handlebar

stem beyond the height

limit.

• Don’t raise the seat post

beyond the height limit.

• Don’t over stress any of the

QR levers.

• Don’t ride it off-road.

236 Hsia Chuan Tze, Yung An,

Hsin Wu, Taoyuan, Taiwan

Tel: +886-3-4861231 Fax: +886-3-4861215

Web: http://www.pacific-cycles.com

Email: [email protected]

Important Safety Checklist!

Check and make sure that all clamps are properly tightened.

1) The handlebars should be tight with no play.

2) The head tube clamp should be fully tightened not allowing rotation or play.

3) The seat stay clamp should be fully tightened (step 4).

4) The seat post clamp should be fully tightened not allowing any rotation or sliding.

Do not raise the handlebar stem and seat post up beyond the maximum insertion mark.

Always wear a helmet and abide by all traffic regulations and courtesies!

Rear carrier max. loading: 10kg / Average speed: 13km/h

Max. height: 185cm / Max. loading: 80kg

Important Maintenance Checklist!

1st service inspection after at most 300 km or at latest one months after purchase,

repeat every 3 months.

Parts need lubrication: chain, headset, bearings.

Parts prohibit lubrication: seatpost, seat tube, adjustable stem, rims.

Repeat lubrication every half month or after at most 150 km ride.

Apply lubrication immediately after washing or riding in rainy day.

Unpack the box - one 95% assembled bike, seat /

seatpost, 1 rear rack, box contains 1 pair of pedals,

rear chassis mounting plate and bolt / washer pack.

Adjust the height and

alignment of handlebar

and seat. You are ready

to go!

Handlebar

Stem

Extension

stem

Headtube

Front carrier /

Bottle cage adaptor

mount

Spring latch

Seat clamp

QR hook

Headtube clamp

Foldable pedal

Crank set

with chain cover

Seat tube

Seat post

Seat clamp QR

Saddle

Seat stay

Rear carrier

Front wheel

Rear wheels

It’s easy to put the Carryall

into the trunk too.

Owner manual 1

Résumé du contenu

Page 1 - Owner manual

Owner manualAssembly ProceduresStep 1: Step 2:Using the small box to fix the frame and put therear chassis as below, set the chainline to front chainw

Modèles reliés CARRYME 2014 | CARRYME 2013 |

Commentaires sur ces manuels

Pas de commentaire

Pacific-cycles CARRYALL Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Pour les vélos Pacific-cycles CARRYALL. Pacific Cycles CARRYALL User Manual Manuel d'utilisatio

Résumé du contenu

Modèles reliés CARRYME 2014 | CARRYME 2013 |

Commentaires sur ces manuels

Produits connexes et manuels pour Pour les vélos Pacific-cycles CARRYALL